A/C and Heater issues with the Air Blend Box

A/C and Heater issues with the Air Blend Box

Hamilton drivers push a few buttons or turn some knobs, and voila! They have air blowing on their feet or cool air chilling their face. But how does all that happen? Well, it’s all thanks to the air blend box. This box lives behind your dash and helps direct the right temperature of air where you want it.

Let’s break it down. First there is the blower fan that circulates your Ontario air through the heating/air conditioning system. The fan can blow at different speeds, depending on how much hot or cold air is comfortable. The blend box can either pull fresh air from outside or recirculate air from inside the cabin. Hamilton drivers often choose to recirculate air when first starting the vehicle until it starts to either cool down or warm up.

Another thing the blend box does is direct air over the heater core to warm the air, or over the air conditioner evaporator core to chill it – or a blend of hot and cold to get it just right. From there the blend box can direct the air out into the passenger compartment through the floor vents, the panel vents, the defroster or a combination. All of this allows Hamilton drivers to customize the climate just the way they like it.

Some vehicles have different climate control zones, like one for the driver and one for the passenger – or even more zones for the back seat. Additional blend boxes are used for this. Climate controls could be manually adjusted or computer controlled depending on your vehicle.

The blower motor and all of the little actuator motors that open and close the various blend doors can fail and need to be replaced. Most new vehicles come with a cabin air filter. This filter cleans the air before it gets into the blend box. If you neglect to change the cabin air filter, it can get clogged, smelly and even allow mildew and other microorganisms to build up in the blend box.

Putney’s Brake and Alignment Service in Hamilton can preform a heating/air conditioning system cleaning service that will clean and disinfect the system, restoring a fresh clean scent. If you are not getting enough hot or cold air, Putney’s Brake and Alignment Service can check your system, diagnose the cause and set things right. And don’t forget to replace the cabin air filter on schedule. If you live and drive in dusty Hamilton conditions or where there is a lot of pollen or other pollutants, you may need to replace your cabin air filter more frequently.

Give us a call 905-523-7535 or Book Online                     http://putneys.ca/appointment-form/ 

Post a comment

Your email address will not be published. Required fields are marked *

Enter Captcha Here : *

Reload Image

X